Product ID:1204 PRIME COAT,PRIMER ADHESIVE
MSDS Date:07/20/1987
FSC:8040
NIIN:01-165-0086
MSDS Number: BJNQS

DOW CORNING CORPORATION

SOUTH SAGINAW ROAD
MIDLAND, MI 48686
US

Emergency Phone: 517-496-5900

Info Phone: 517-496-5900

Preparer: JACK SHENEBERGER

Cage: 5D028

DOW CORNING CORP

AUBURN, MI 48611 US

Telephone: 517-496-4388

Cage: 71984

2-METHOXYETHYLORTHOSILICATE.MFR REC TO OBSERVE LIMITS

Fraction By Weight: 4%

OSHA PEL 25 PPM SKIN

ACGIH TLV: 5 PPM SKIN

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 2%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 19%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

VM&P NAPHTHA (LIGROINE)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: 65%

OSHA PEL 300 PPM/400 STEL

ACGIH TLV: 300 PPM; 9192

LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:VAPORS (PRLNG OVEREXPOS TO TOLUENE)
MAY INJURE BLOOD,LUNGS,LIVER,KIDNEYS & NERVOUS SYSTEM.EFFECTS
DEPEND ON CONC & LENGTH OF EXPOSURE.INHALING LIQ WHILE VOMITING CAN
INJURE LUNGS SERIOUSLY.2-METHOXYET HANOL MAY FORM UPON
HYDROLYSIS.2-METHOXYETHANOL:KNOWN TO CAUSE REPRO DISORDERS
(MALE,DEVELOPMENTAL) (CAL PROP 65,1989).
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRIT.POSS SERIOUS W/ REDNESS,SWELLING &
SOME CORNEAL INJURY LASTING DAYS TO A WEEK.SKIN:SINGLE,SHORT
EXPOS-NO KNOWN ADVERSE EFFECTS.SEV RPTD EXPOS (24-48 HRS) MAY
IRRITATE.INGEST:SMALL AMT TRANS FERRED TO MOUTH BY FINGERS SHOULD
NOT INJURE.LRG AMT MAY INJURE SLIGHTLY.INHAL OF VOMITUS CAN
SERIOUSLY INJURE.(SEE SUP)
Medical Cond Aggravated by Exposure:PROLONGED OVEREXPOSURE TO TOLUENE
MAY AGGRAVATE EXISTING EYE,SKIN AND RESPIRATORY DISORDERS.

First Aid:EYES: FLUSH W/ WATER MIN 15 MINUTES.GET IMMEDIATE MED
ATTN.SKIN:IMMEDIATELY WIPE OFF & FLUSH W/ WATER.INGEST:GET
IMMEDIATE MED ATTN IF LARGE AMOUNT SWALLOWED.DO NOT INDUCE
VOMITING.INHAL OF VOMITUS CA N INJURE LUNGS SERIOUSLY.IF VOMITING
OCCURS,KEEP HEAD LOWER THAN HIPS TO PREVENT ASPIRATION OF LIQUID
INTO LUNGS.INHALATION:REMOVE TO FRESH AIR.GET IMMEDIATE MEDICAL
ATTENTION IF ILL EFFECTS PERSIST.

Flash Point Method:CC
Flash Point:59F,15C
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:WATER FOG,CO*2,DRY CHEMICAL AND FOAM.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:VAP HEAVIER THAN AIR-CAN TRAVEL ALONG
GROUND TO REMOTE IGNIT SOURCE.HAZ DECOMP PROD:METAL OXIDES,SILICON
DIOXIDE,CO*2,TRACES OF INCOMPLETELY BURNED CARBON PROD.

Spill Release Procedures:COLLECT W/ ABSORB MATL & CONTAIN FOR SALVAGE
OR DISP.REMOVE ALL IGNIT SOURCES & WEAR PROPER PROT EQUIP.PRODUCT
IS AN OIL.REPORT SPILL TO US SURFACE WATERS OR TO WATERCOURSE OR
SEWERS LEADING TO US SUR FACE WATERS THAT CAUSE VISIBLE SHEEN
TO(SEE SUPP)
Neutralizing Agent:N/K

Handling and Storage Precautions:KEEP CONTAINER CLOSED & AWAY FROM
HEAT,SPARKS & OPEN FLAME.AVOID BREATHING VAPORS AND EYE & SKIN
CONTACT.USE ONLY W/ ADEQ VENT.DO NOT TAKE INTERNALLY.
Other Precautions:STATIC ELECTRICITY MAY ACCUMULATE AND CREATE A FIRE
HAZARD.GROUND FIXED EQUIPMENT.BOND AND GROUND TRANSFER CONTAINERS
AND EQUIPMENT.PREC ARE FOR ROOM TEMP HANDLING,USE AT ELEVATED
TEMP,OR AEROSOL/SPRA Y APPLIC,MAY REQUIRE ADDED PRECAUTIONS.

Respiratory Protection:ORGANIC VAPOR TYPE.USE RESPIRATORY PROTECTION
UNLESS LOCAL EXHAUST VENTILATION IS ADEQUATE OR AIR SAMPLING DATA
SHOW EXPOSURES WITHIN TLV AND PEL GUIDELINES.
Ventilation:LOCAL AND GENERAL (MECHANICAL) EXHAUST RECOMENDED.
Protective Gloves:RUBBER/PLASTIC MIN;WASH IMMED ON CONT.
Eye Protection:MIN.CHEM SAFETY GOGGLES.AND FACE SHIELD)
Other Protective Equipment:USE IMPERVIOUS PROT CLTHG:RUBBER OR PLASTIC
GLOVES,APRONS,BOOTS,ETC.
Work Hygienic Practices:GOOD PRACTICE REQUIRES REMOVAL OF GROSS AMOUNT
OF ANY CHEM FROM SKIN AS SOON AS PRACTICAL,ESP BEFORE EATING OR
SMKNG.
Supplemental Safety and Health
VP:APPROX 25 MMHG AT 77F,25C.% VOLAT BY WT:APPROX 95.ENTRY
RTE:INHAL/SKIN/INGEST .EFTS OF OVEREXPOS:INHAL:SHORT EXPOS MAY
CAUSE DROW,NOSE/THROAT IRRIT.SPILL PROC:NATL RESPONSE
CENTER.REPORTABLE RELEASE OF TOLUENE/1-BUTANOL BEYOND FACILITY
BOUNDARIES MAY BE REPORTABLE TO STATE OR LOCAL EMERGENCY RESPONSE
AUTH.

Boiling Pt:B.P. Text:210F,99C
Decomp Temp:Decomp Text:N/K
Vapor Pres:SEE SUPP
Vapor Density:3.8,AIR=1
Spec Gravity:0.77 (WATER=1)
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:LIGHT STRAW COLORED LIQUID WITH SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.ALSO AVOID WATER OR MOISTURE.
Stability Condition to Avoid:EXPOSURE TO AIR UNTIL READY TO USE.
Hazardous Decomposition Products:METAL OXIDES,SILICON DIOXIDE,CARBON
DIOXIDE AND TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.

Waste Disposal Methods:DISP MUST BE IAW FED,STATE,& LOC
REGS.COORDINATION W/ SUPPORTING INSTALLATION/MACOM ENVIRONMENTAL
COORDINATION PRIOR TO DISPOSAL IS REC TO DETERMINE APPROP DISP
METHODS .CONTACT DOW CORNING W/ A NY QUESTIONS.TOLUENE AND
1-BUTANOL:SARALISTED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.